international harvester 3800 1995 უსაფრთხოების დეფექტების სია აშშ-ში

მიზეზი

THE FRONT WHEEL HUB CAN DEVELOP CRACKS AT THE WHEEL MOUNTING STUDS. WHEN MOUNTED TO THE HUB, THE HYDRAULIC BRAKE DISC ROTOR DOES NOT PROPERLY SUPPORT THE HUB AT THE WHEEL STUDS CAUSING EXCESSIVE STRESS AND FATIGUE CRACKS IN THE HUB.

შედეგი

-

გადაწყვეტილება

DEALERS WILL INSTALL NEW, REDESIGNED HUBS ON THESE VEHICLES.

შენიშვნა

SYSTEM: WHEELS; HUB. VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES AND MEDIUM DUTY TRUCKS BUILT WITH 9,000, 10,000, 11,000 OR 12,000 POUND FRONT AXLE, HYDRAULIC DISC BRAKES, AND HUB MOUNTED DISC WHEELS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREEDUPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT NAVISTAR AT 1-800-448-7825. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

მიზეზი

THE WIRING FROM THE ELECTRONIC CONTROL UNIT WAS CONNECTED TO THE WRONG WHEEL SENSOR OR TO THE WRONG BRAKE MODULATOR VALVE. IT IS POSSIBLE THAT EITHER OR BOTH WIRING MAY HAVE OCCURRED AT EITHER THE FRONT OR REAR AXLE OR BOTH AXLES.

შედეგი

-

გადაწყვეტილება

DEALERS WILL INSPECT THE ABS WIRING AND, IF NECESSARY, PROPERLY CONNECT.

შენიშვნა

OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 1996.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NAVISTAR AT 1-800-448-7825.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

მიზეზი

FOUR COMPRESSION BACKPLATE RETAINING FASTENERS ON THE TURBO-CHARGER WERE TORQUED ONLY HAND TIGHT. THIS ALLOWS THE FASTENERS TO LOOSEN, AND CAUSES OIL TO LEAK INTO THE COMPRESSOR AIR SIDE OF THE TURBO-CHARGER WHICH, WHEN COUPLED WITH THE HEAT PRECIPITATED BY THE COMPRESSOR AND THE MIXING ACTION OF THE COMPRESSOR WHEEL, CAN RESULT IN AN AIR/OIL MIXTURE THAT FUELS THE ENGINE.

შედეგი

-

გადაწყვეტილება

REPLACE THE SUSPECT TURBO-CHARGER WITH A NEW TURBO-CHARGER.

შენიშვნა

SYSTEM: ENGINE; TURBO-CHARGER.VEHICLE DESCRIPTION: TRUCKS AND BUSES EQUIPPED WITH NAVISTAR I-6 ENGINES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT NAVISTAR AT 1-800-448-7825. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

მიზეზი

THESE BUSES WERE BUILT WITH AN ADDITIONAL 3/4 INCH THICK PLYWOOD FLOOR AND EXTRA THICK FLOOR MATS FOR INCREASED INSULATION DURING COLD WEATHER. THE BOTTOM EDGE OF THE ACCELERATOR PEDAL, WHEN DEPRESSED, CAN COME IN CONTACT WITH THE HEAD OF A BOLT SECURING THE TRANSMISSION COVER TO THE FLOOR. THE ENGINE THROTTLE MAY NOT RETURN TO THE IDLE POSITION.

შედეგი

-

გადაწყვეტილება

DEALERS WILL REMOVE 1/2 INCH FROM THE BOTTOM OF THE ACCELERATOR PEDAL.

შენიშვნა

SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; PEDAL.VEHICLE DESCRIPTION: BUSES AND SCHOOL BUSES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT NAVISTAR SERVICE CENTER AT 1-800-448-7825. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.