ford taurus 1986 Recalls Check Results

SUMMARY

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

CONSEQUENCE

-

REMEDY

DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.

NOTES

NOTE:THIS RECALL CAMPAIGN SUPERCEDES RECALL CAMPAIGN 93V-106.OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 18, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

SUMMARY

CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.

CONSEQUENCE

-

REMEDY

REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.

NOTES

SYSTEM: STRUCTURE: STORAGE COMPARTMENTS.VEHICLE DESCRIPTION: PASSENGER CARS (STATION WAGONS).NOTE: FORD WILL HAVE SUFFICIENT QUANTITIES OF THE NEW LATCH ASSEMBLIES AVAILABLETO BEGIN THE REPLACEMENT RECALL IN JULY, 1992. UNTIL THE LATCH ASSEMBLY ISREPLACED, FORD RECOMMENDS OWNERS LOCK THE STORAGE COMPARTMENT WHEN NOT IN USE.ALSO, FORD ADVISES THAT THE LATCH STRIKER CAN BE REMOVED TO DISABLE THE CURRENTLATCH UNTIL REVISED LATCH ASSEMBLIES ARE AVAILABLE.

SUMMARY

FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.

CONSEQUENCE

-

REMEDY

REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.

NOTES

SYSTEM: BRAKES.VEHICLE DESCRIPTION: PASSENGER VEHICLES SOLD OR REGISTERED IN THE FOLLOWING STATES: CT, IL, IN, ME, MA, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.

SUMMARY

THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.

CONSEQUENCE

-

REMEDY

MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.

NOTES

EQUIPMENT DESCRIPTION: AFTERMARKET SHOCK ABSORBERS FOR 1986 - 1994 FORD TAURUS AND MERCURY SABLE PASSENGER CARS; PART 71780, 81780.IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT MONROE AT 1-800-521-6754. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

SUMMARY

VEHICLE DESCRIPTION: TAURUS AND SABLES BUILT FROM 10-14-85 THROUGH 8-19-88, AND LINCOLN CONTINENTALS BUILT FROM 11-4-87 THROUGH 9-30-88 (EXCEPT 1989 - 1991 2.5L TAURUS AND 1989 - 1992 SHO). THE AFFECTED CARS WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, MAY BECOME DETACHED DUE TO CORROSION OF THE SUBFRAME MOUNT RETAINING PLATE. THIS WOULD ALLOW THE REAR CORNERS OF THE SUBFRAME TO DROP.

CONSEQUENCE

-

REMEDY

INSTALL A CORROSION-RESISTANT REINFORCING PLATE AND A NEW BOLT ON BOTH REAR SUBFRAME MOUNTS. THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY RECALL 98V-323.

NOTES

THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY RECALL 98V-323.

SUMMARY

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

CONSEQUENCE

-

REMEDY

INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

NOTES

SYSTEM: FUEL LINE COUPLINGVEHICLE DESCRIPTION: PASSENGER CARS AND LIGHT TRUCKS EQUIPPED WITH FUELINJECTION.

SUMMARY

THE RIGHT QUARTER WINDOWS MAY CONTAIN GLASS WHICH WAS IMPROPERLY TEMPERED. THIS GLASS MAY YIELD PIECES LARGER THAN THE MAXIMUM ALLOWED BY FMVSS 205, GLAZING MATERIAL. CONSEQUENCE OF DEFECT: IN CASE OF AN ACCIDENT THESE LARGE PIECES OF GLASS MAY SERIOUSLY INJURE THE OCCUPANTS OF THE CAR.

CONSEQUENCE

-

REMEDY

REPLACE THE QUARTER WINDOWS CONTAINING DATE CODE 5 AF.

NOTES

SYSTEM: WINDOW GLAZING/FMVSS 205. VEHICLE DESCRIPTION: STATION WAGONS EQUIPPED WITH 5 AF DATE CODE RIGHT SIDE TINTED QUARTER WINDOW GLASS.

SUMMARY

ROAD SALT INDUCED EROSION OF THE WIPER MOTOR CONDUCTOR STRIPS COULD CAUSE LOCALIZED THERMAL STRESS WITHIN THE GLASS.

CONSEQUENCE

-

REMEDY

APPLY SEALANT TO CONDUCTOR STRIPS AND PROTECTIVE TAPE TO LOWER BACKLITES.

NOTES

SYSTEM: REAR WINDOW WIPER MOTOR.VEHICLE DESCRIPTION: STATION WAGONS EQUIPPED WITH OPTIONAL REAR WINDOW WIPERMOTORS.

SUMMARY

-

CONSEQUENCE

-

REMEDY

IGNITION LOCK SWITCH CYLINDER WILL BE REPLACED.

NOTES

SYSTEM: LOCK, IGNITION SYSTEM, FMVSS 114. VEHICLE DESCRIPTION:PASSENGER CAR.DESCRIPTION DEFECT:THE IGNITION KEY CAN BE REMOVED FROM THE IGNITION SWITCH IN POSITIONS OTHER THAN THE LOCK POSITIONS.FMVSS 114 REQUIRES THAT WHEN THE KEY IS REMOVED FROM THE IGNITION SWITCH THAT EITHER THE STEERING OR TRANSMISSION BE LOCKED.REMOVAL OF THE KEY WHEN NOT IN THE LOCK POSITION LEAVES THE STEERING AND TRANSMISSION IN THE NORMAL OPERATING MODE.